欢迎光临华盈非晶合金变压器有限公司!

[email protected]

非晶合金干式变压器厂家联系方式

通讯地址:山东聊城经济开发区华山路南首30号
固定电话:0635-8888299
传真号码:0635-8888109
移动电话:13287501888 
联系人:陈经理
电子邮箱:[email protected]



新闻详细/伊犁干式变压器:伊犁干式变压器油箱密封试验

伊犁干式变压器:伊犁干式变压器油箱密封试验

网站编辑:伊犁华盈非晶合金变压器有限公司 │ 发表时间:2020-07-29

伊犁干式变压器油箱密封试验   
油箱密封性试验应在装配完毕后进行。带有可拆卸的散热器或冷却器时,可以在拆卸状态下试验,试验用静油柱法或静气压法。

1.静油柱法
静油柱试验法是在伊犁干式变压器储抽柜的注油孔上加装一根高度为0.6m以上的油管,在油管顶端焊装一个贮油桶,以备伊犁干式变压器油因热胀冷缩或绕组内气泡溢出作补充用,防止造成缺油。这样经24h后观察应无渗油现象。此方法一般用在160kVA以上的伊犁干式变压器。

2.静气压法
静气压法是在伊犁干式变压器箱盖上或储油柜上的通气孔连接一个带有气压表的管子,端部装有旋塞,缓慢施以气压到0. 03MPa,然后将旋塞关闭,经24h观察,油箱各处不得发现有渗漏现象。所有气体(空气或惰性气体)必须是干燥的。气压试验时,应将储油柜与油箱相连通,有安全气道的要将玻璃板换成钢板密封。一般是将储油柜上吸湿器拆去.接三通接头.将氮气瓶中氮气经降压表阀降压后通入储抽柜或胶囊袋中,关闭阀门,观压压力表12h不显著降低。对密封式有波纹油箱的伊犁干式变压器,应加0.025MPa压力12h不渗漏。而按国家标准GBJ148-1990《伊犁干式变压器验收规范》规定,伊犁干式变压器箱盖上加0.03MPa24h伊犁干式变压器本体不渗漏,有载分接伊犁干式变压器加0.06MPa24h不渗漏。在做密封试脸前,有时要抽真空,它们单位的相互关系。

1nunHg = 133. 322Pa
lat(工程大气压)=0.0980665MPa≈0.1MPa
1mm(标准大气压)=0. 101325MPa

Tank seal test

Tank tightness test after assembly. Demolition state with a detachable radiator or cooler, you can test, test static oil column method or static pressure method.

A static oil column method
Static oil column test method is to install a height of 0.6m above the tubing on the filling hole of the transformer storage drawers, a jerry can in the tubing to the top welding to prepare for transformer oil bubble due to thermal expansion and contraction or winding overflow to supplement, to avoid creating short of oil. So that after 24h observation should be no oil leakage. This method is generally more than 160kVA transformer.

(2) static pressure method
Static pressure method is to connect the transformer cover or oil storage cabinet vent pipe with a barometer, the end is equipped with cocks, slow to impose pressure to 0. 03MPa, then cocks Close, observed after 24h, tank throughout not found to have leakage. Gas (air or inert gas) must be dry. Pressure test, the storage cabinet should be connected to the tank through secure airway to the glass replaced with steel plates sealed. Generally, oil storage cabinet dehumidifiers remove them. Pick the tee. Nitrogen bottle of nitrogen through the valve buck buck table access storage drawers or capsule bag, close the valve, the concept of pressure pressure gauge 12h was not significant reduced. 0.025MPa pressure 12h does not leak sealed corrugated tank transformer, should be added. And nati手 机:13287501888onal standards GBJ148-1990 transformer acceptance of the provisions of the transformer cover plus 0.03MPa24h transformer body does not leak, OLTC to add 0.06MPa24h not leak. In sealed test face, and sometimes to the vacuum, the mutual relations of their units.
1nunHg = 133. 322Pa
of lat (works atm) = 0.0980665MPa ≈ 0.1MPa
1mm (standard atmospheric pressure) = 0. 101325MPa

更多伊犁干式变压器资讯:上海伊犁干式变压器厂家伊犁干式变压器产品伊犁干式变压器资讯

通讯地址:山东聊城经济开发区华山路南首30号
固定电话:0635-8888299
传真号码:0635-8888109
移动电话:13287501888 
联系人:陈经理
电子邮箱:[email protected]



Copyright © 2017 伊犁非晶合金变压器_伊犁干式变压器_华盈非晶合金变压器有限公司  技术支持:互联纵横

<meta name="wlhlauth" content="26b08b3170bb57da2daa8fd2903c5785"/>